Product ID:E61 R 26, KEM FLASH PRIME RED OXIDE
MSDS Date:12/15/1986
FSC:8010
NIIN:00N032339
MSDS Number: BNSNX

SHERWIN-WILLIAMS CO

101 PROSPECT AVE NW
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

EXPOSURE LIMITS. REFER TO OSHA STANDARDS 1910.94,

RTECS: 9999999ZZ

12

CAS: 64742-48-9

Fraction By Weight: 30-35%

OSHA PEL 300 PPM;400 PPM STEL

ACGIH TLV: 300 PPM

KEROSENE (PETROLEUM), HYDROTREATED ; (MINERAL SPIRITS).

CAS: 64742-47-8

RTECS: OA5504000

Fraction By Weight: <5%

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 100 PPM (MFR)

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <5%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0-15%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

INFORMATION & SAFE HANDLING & EXPOSURE

RTECS: 9999999ZZ

REGARDING POLLUTION.

RTECS: 9999999ZZ

ELEC TOOLS/APPLIANCES & ANY OTHER SOURCES OF

RTECS: 9999999ZZ

PROCEDURES. TRANSFER ONLY TO APPRVD CONTRS W/COMPLETE

RTECS: 9999999ZZ

OF THE REACH OF CHILDREN. THIS COATING CONTAINS MATLS

RTECS: 9999999ZZ

PRESENT AT HAZ LEVELS ONLY DURING SANDING/ABRADING OF

RTECS: 9999999ZZ

CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:OVEREXPOS CAUSES EYE, SKIN &
RESP IRRIT. MAY CAUSE NERV SYS DEPRESS ACCOMPANIED BY HDCH, DIZZ,
NAUS, CONFUSN & STAG GAIT. EXTREME OVEREXPOS MAY RSLT IN UNCON &
POSS DEATH. CHRONIC: PRLNGD OVEREX POS TO INGREDS IN INGRED SECTION
MAY CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD FORMING & CVS. RATS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EXPOSED TO TITANIUM DIOXIDE DUST AT
250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH EXPOS LEVELS ARE NOT
ATTAINABLE IN THE WORKPLACE. RPTS HAVE ASSOC RPTD/PRLNGD OVEREXPOS
TO SOLV W/PERM BRAIN & NERV SYS DAM. NOTE:TOLUENE 108-88-3 APPEARS
ON THE NAVY LISTING OF OCCUP REPROD HAZARDS. SEEK CONSULTATION (SUP
DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/ SOAP &
WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. EYES:
FLUSH W/LA RGE AMOUNTS OF WATER FOR AT LEAST 15 MINS. GET MEDICAL
ATTENTION. INGEST:CALL MD IMMEDIATELY .

Flash Point Method:PMCC
Flash Point:50.0F,10.0C
Lower Limits:0.9%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL & FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE
PREFERABLE. WATER MAY BE USED TO COOL (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT (SUPP DATA)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM
HEAT, SPARKS & OPEN FLAME. KEEP CONTR CLSD WHEN NOT IN USE. USE
ONLY W/ADEQ VENT. AVOID CONT W/SKIN & EYES.
Other Precautions:AVOID BRTHG VAP/SPRAY MIST. PROT AGAINST DUST WHICH
MAY BE GENERATED BY SANDING/ABRADING DRIED FILM. DURING USE & UNTIL
ALL VAPS ARE GONE:KEEP AREA VENTD. DO NOT SMOKE. EXTING ALL FLAMES,
PILOT LIGHTS & HEATERS. TURN OFF STOVES, (ING 7)

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR NIOSH/MSHA APPROVED
RESPIRATORY DEVICES FOR PROTECTION AGAINST MATERIALS IN INGREDIENT
SECTION.
Ventilation:LOC EXHST PREFERABLE. GEN EXHST ACCEPTABLE IF EXPOS TO
MATLS IN INGRED SECTION IS MAINTAINED BELOW APPLIC (ING 12)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:CLSD CONTRS TO PVNT PRESS BUILD-UP/POSS
AUTOIGNIT/EXPLOS WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:SURF REQS
SPEC PRECS. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE
HLTH HAZ. SY MPS MAY NOT BE IMMED APPARENT. SEE MD. EFTS OF
OVEREXP:FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST
(ING 5)

HCC:F3
Boiling Pt:B.P. Text:>222F,>106C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.198-1.32
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:63

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CO2 & CO.

Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40CFR261. WASTE MUST BE TESTED FOR IGNITABILITY & EXTRACTABILITY TO
DETERM APPLIC EPA HAZ WASTE NOS. INCIN IN APPRVD FACILITY. DO NOT
INCIN CLSD CONTR. DISP OF I/A/W FED, STATE & LOC REGS (ING 6)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.